​MATERIAL SAFETY DATA SHEET

DATE PREPARED: 03/10/18
________________________________________________________________________________________

SECTION 1                                             IDENTIFICATION OF PRODUCT



TRADE NAME:                                          BLACK PKA POOMA ANODIZING DYE

COLOUR INDEX GENERIC NAME:           ACID BLACK

CAS No.:                                                   61931-02-0





SECTION I                                WARNING



IT MAY CAUSE IRRITATION WHEN IT COMES IN CONTACT WITH EYE OR SKIN.

___________________________________________________________________________________________

SECTION III                                HAZARDOUS INGREDIENTS



NONE AS PER 29 CFR PART 1910/200 (OSHA HAZARD COMMUNICATIONS STD.)

___________________________________________________________________________________________



SECTION IV                                BANNED AMINES CONTENT



THIS PRODUCT DOES NOT CONTAIN THE FOLLOWING TOXIC CHEMICALS SUBJECT TO THE REPORTING

REQUIREMENTS OF SECTION 313 OF THE EMERGENCY PLANNING AND COMMUNITY RIGHT-TO-KNOW ACT

OF 1986 AND OF 40 CFR 372:



    4 AMINO DIPHENYL      BENZIDINE                    4 CHLORO TOLUDINE

   2 NAPHTHYLAMINE      0-AMINOAZO TOLUOL     2 AMINO-4-NITRO TOLUOL
   P-CHLORANILINE         2,4 DIAMINO ANISOLE    4,4 DIAMINODIPHENYL METHANE



  3,3 DICHLOROBENZIDINE             3,3 DIMETHOXY  BENZIDINE

  3,3 DIMETHYL BENZIDINE             PARACRESIDENE
  4,4 OXYDIANILINE                         4,4 THIO DIANILIN
  0-TOLUDINE                                  2,4 TOLUYLENDIAMINE



22,4,5 TRIMETHYANILINE

   3,3  DIMETHYL 4,4 DIAMINO DIPHENYL METHANE
  4,4  METHYLENE  BIS (2 CHLORANILIN)

___________________________________________________________________________________________



SECTION V                                   PHYSICAL DATA 



APPEARANCE:                           BLACK POWDER

ODOUR:                                      NONE

PH:                                              NEUTRAL

 

_________________________________________________________________________________________________________________________



SECTION VI                                 FIRE AND EXPLOSION HAZARD INFORMATION



FLASH POINT:                             NOT APPLICABLE

EXTINGUISHING MEDIA:              FOAM CO2 DRY CHEMICAL OR WATER SPRAY 



-UNUSUAL HAZARDS:

HANDLE CAREFULLY TO AVOID DUSTING CONDITIONS. MAY FORM EXPLOSIVE MIXTURES WITH AIR (IF MIXED IN CRITICAL PROPORTIONS AND IN PRESENCE OF IGNITING AGENT.)       

 _________________________________________________________________________________________  



SECTION VII                                  RE ACTIVITY DATA 



​STABILITY:                                                         STABLE UNDER NORMAL CONDITIONS

HAZARDOUS POLYMERIZATION:                       WILL NOT OCCUR

INCOMPATIBLE MATERIAL:                                STRONG OXIDIZING AGENTS       

HAZARDOUS DECOMPOSITION PRODUCTS:     COMBUSTION WILL PRODUCE OXIDES OF CARBON & NITROGEN



___________________________________________________________________________________________



SECTION VIII                                   HEALTH HAZARD INFORMATION

-TOXICOLOGICAL DATA:

RAT LD50  z(ORAL): -5000 MG/KG

RABBIT, SKIN: NON IRRITATING 

RABBIT, EYES: NON IRRITATING



​-EFFECTS OF OVER EXPOSURE:

THIS PRODUCT IS NOT LISTED AS CARCINOGEN OR POTENTIAL BY NIP, IARC OR OSHA. IT HAS BEEN FOUND TO BE NON MUTAGENIC IN AMESO TEST. NO OTHER HEALTH HAZARDS ARE CURRENTLY KNOWN TO US, HOWEVER, ANY MATERIAL THAT GETS INTO EYES OR ON SKIN MAY CAUSE IRRITATION.

HANDLE THIS PRODUCT WITH CARE AND AVOID UNNECESSARY EXPOSURES. 



-EMERGENCY FIRST AID PROCEDURE:



*INHALATION: REMOVE TO FRESH AIR, IF DIFFICULTY IN BREATHING, ADMINISTER OXYGEN AND GET IMMEDIATE MEDICAL ATTENTION. 



*INGESTION: GET IMMEDIATE MEDICAL ATTENTION.



*SKIN: WASH THOROUGHLY WITH SOAP  AND WATER FOR FIFTEEN MINUTES. SEEK MEDICAL ATTENTION.



*EYES: FLUSH IMMEDIATELY UNDER RUNNING WATER FOR FIFTEEN MINUTES. SEEK MEDICAL ATTENTION.

___________________________________________________________________________________________



SECTION IX                                        SPILL AND LEAK PROCEDURE



-STEPS TO BE TAKEN IF MATERIAL IS RELEASED:

SWEEP OR SHOWER SPILLS USING A MOIST ABSORBENT TO PREVENT DUSTING LOAD THE SPILL IN A WASTER DISPOSAL CONTAINER AS PER RULE.



-WASTE DISPOSAL METHOD:

DISPOSAL MUST BE IN ACCORDANCE WITH ALL APPLICABLE GOVERNMENT RULES.

___________________________________________________________________________________________



SECTION X                                         SPECIAL PROTECTION INFORMATION



​-RESPIRATORY:

WEAR A NOISH APPROVED DUST RESPIRATOR OR A DUST MASK IF DUSTY CONDITIONS ARE PRESENT.



​-VENTILATION:

USE EXHAUST TO MINIMIZE EXPOSURE.



-OTHER PROTECTIVE MEASURES:

EYE PROTECTION  WEAR  SAFETY  GLASSES, RUBBER  OR PLASTIC GLOVES, APRON, WORK  CLOTHES      WITH   LONG SLEEVED SHIRT TO AVOID SKIN CONTACT.       

-NOTE:

STATION SHOULD BE EASILY  ACCESSIBLE.  SHOWER AFTER HANDLING THIS PRODUCT. WASH WELL BEFORE EATING.

___________________________________________________________________________________________



SECTION XI                                     HAZARD RATINGS



HMIS: HEATLH: 1                                 SARA TITLE III ACUTE: NO

FIRE: 1                                                CHRONIC: NO

RE ACTIVITY: 0                                   FLAMMABILITY: NO                         

PERSONNEL PROTECTION: SD         PRESSURE: NO

___________________________________________________________________________________________

       

DISCLAIMER:



THIS INFORMATION IS BASED ON DATA AVAILABLE TO AND IS BELIEVED TO BE  TRUE AND  ACCURATE. THE INFORMATION CONTAINED HEREIN IS OFFERED  IN  GOOD  FAITH AND  NO WARRANTY, EXPRESSED OR IMPLIED, ARE MADE REGARDING THE ACCURACY  OF THIS DATA.  SINCE CONDITIONS OF USE ARE BEYOND CONTROL,WE  ASSUMES  NO RESPONSIBILITY FOR THE USE OR  HANDLING  OF  THIS  PRODUCT.